Parts Bench › Parts › 2011 Ford Fusion
2011 Ford Fusion parts
Common replacement parts for the 2011 Ford Fusion, what usually wears out, a general maintenance schedule, and where to shop. Parts can differ by engine, trim and build date, so confirm fitment with your VIN before you buy.
Shop the 2011 Ford Fusion in the appPopular parts
Brakes
- Front Brake Pads
- Rear Brake Pads
- Front Brake Rotors
- Rear Brake Rotors
- Front Brake Caliper
- Brake Master Cylinder
Ignition & Starting
Electrical & Charging
Cooling
Belts & Pulleys
Engine
Fuel System
Air Intake & Turbo
Maintenance
Exhaust & Emissions
Sensors & Modules
Steering
Suspension
Drivetrain & Axles
Heating & A/C
Lighting
Body & Exterior
General maintenance schedule
These are common starting intervals, not a factory schedule for your engine. Your owner's manual always wins.
| Engine oil & filter | Every 5,000 miles or 6 months Use the oil grade and spec in your owner's manual. Some engines allow longer. |
|---|---|
| Tire rotation | Every 7,500 miles or 6 months Also a good time to check tread depth and pressures. |
| Brake inspection | Every 12,000 miles or 1 year Pads, rotors, lines and fluid level. |
| Cabin air filter | Every 15,000 miles or 1 year Sooner if the airflow smells musty or feels weak. |
| Engine air filter | Every 20,000 miles or 2 years Sooner on dusty or gravel roads. |
| Wiper blades | Every 1 year |
| 12V battery test | Every 3 years Most 12V batteries last 3 to 5 years. Test before winter. |
| 12V battery replaced | Every 5 years Most last 3 to 5 years. Heat and short trips wear them faster. |
| Tires (replace) | Every 50,000 miles or 6 years Tread depth and age matter more than miles. Replace at 2/32" of tread (4/32" if you drive in the rain a lot), or around 6 years old. The date code is on the sidewall. |
| Brake pads (replace) | Every 40,000 miles Replace when about 3 mm (1/8 in) of pad is left, or if you hear grinding. Rear pads usually last longer than front. |
| Brake rotors (replace) | Every 70,000 miles Replace below the minimum thickness stamped on the rotor, or if warped or deeply grooved. Often done with new pads. |
| Shocks & struts (replace) | Every 75,000 miles Worn ones cause bouncing, nose-dive when braking and uneven tire wear. Many last 50,000 to 100,000 miles. |
| Brake fluid flush | Every 30,000 miles or 2 years Brake fluid absorbs moisture over time. |
| Spark plugs | Every 60,000 miles Iridium or platinum plugs often go 100,000 miles. Check the manual. |
| Transmission fluid | Every 60,000 miles Interval varies a lot by transmission. Check the manual. |
| Coolant flush | Every 60,000 miles or 5 years Some long-life coolants go 100,000+ miles. |
| Serpentine belt | Every 90,000 miles Inspect for cracks at every oil change. |
| Timing belt (if equipped) | Every 90,000 miles or 7 years Skip if your engine has a timing chain. Check the manual. |
Safety recalls
NHTSA lists 9 recalls for the 2011 Ford Fusion. Recalls apply by model year, and not every vehicle of that year is affected. Check your own VIN at nhtsa.gov/recalls.
- AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE (19V001000): Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto…
- AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE (16V384000): Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford…
- STEERING:ELECTRIC POWER ASSIST SYSTEM (15V340000): Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, L…
- FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK (15V793000): Ford Motor Company (Ford) is recalling certain model year 2010-2011 Ford Fusion vehicles manufactured July 21, 2008, to March 4, 2011, and 2010-2011 Mercury Milan vehicles manufactured July 23, 2008, to December 10, 2…
- EQUIPMENT (14E028000): Ford Motor Company (Ford) is recalling certain all weather driver side accessory floor mats sold for use in model year 2006-2011 Ford Fusion and Mercury Milan, 2006 Lincoln Zephyr, and 2007-2011 Lincoln MKZ vehicles m…
- WHEELS:LUGS/NUTS/BOLTS/STUDS (11V574000): FORD IS RECALLING CERTAIN MODEL YEAR 2010-2011 FORD FUSION AND MERCURY MILAN VEHICLES EQUIPPED WITH 17 INCH STEEL WHEELS AND BUILT FROM APRIL 1, 2009, THROUGH APRIL 30, 2009, AND FROM DECEMBER 1, 2009, THROUGH NOVEMBE…
Showing 6 of 9.
Other Ford Fusion years
Parts Bench is a free tool for identifying a vehicle, tracking maintenance and finding parts. Open the app to save your vehicle and keep a maintenance log.
Links to eBay and other stores are affiliate links. We may earn a commission if you buy, at no extra cost to you. Parts Bench is not a store and does not sell parts. Always confirm fitment with the seller before you buy.